Top Equipments




Popular searches

Section 902 AGGREGATES

of natural aggregate, blast furnace slag, crushed concrete, or reclaimed asphalt pavement with particle sizes no greater than 2 inches and no visible organic or foreign matter Manufactured Fine Aggregate One hundred percent crushed rock, gravel, iron blast furnace slag, reverberatory furnace slag, steel furnace slag, or portland cement concrete...

Know More

Use of Steel Slag Aggregate in Pavements Report

The slag produced is very angular and porous with a rough surface texture Figure 1 The chemical properties of the aggregates vary depending on the furnace, feed stock and slag formers used to produce the steel The aggregate formed from the slag is comprised of calcium oxide CaO , silicon oxide SiO 2 , iron oxide Fe 2 O 3...

Know More

5 Aggregate Specifications and Requirements

Air cooled blast furnace slag fine aggregate 26 Granulated blast furnace slag fine aggregate 21 Steel furnace slag, both fine and coarse 32 Gravel Coarse Aggregates There is a specific requirement for gravel coarse aggregates regarding crushed particl...

Know More

Blast Furnace Slag

Air-Cooled Blast Furnace Slag Crushed ACBFS is angular, roughly cubical, and has textures ranging from rough, vesicular porous surfaces to glassy smooth surfaces with conchoidal fractur There can, however, be considerable variability in the physical properties of blast furnace slag, depending on the iron production process...

Know More

Feasibility Study of Dephosphorization of Slag Generated ,

Afterward it was cooled to 1400 176 C at the rate of 1 176 C/min with holding period of 240 min and then quenched with water The cooled slag was then crushed, milled and separated by wet magnetic separation method Since the magnetic properties differ for different phases, it is possible to separate each phase with the aid of magnetic separation By ....

Know More

COMPARISON OF PROPERTIES OF STEEL SLAG AND CRUSHED ,

COMPARISON OF PROPERTIES OF STEEL SLAG AND CRUSHED LIMESTONE AGGREGATE CONCRETES Steel slag is produced as a by-product during the oxidation of steel pellets in an electric arc furnace This by-product that mainly consists of calcium carbonate is broken down to smaller sizes to be used as aggregates in asphalt and concrete...

Know More

Technical Note TN 009

has similar appearance and properties to igneous rock The steel slag is crushed to size and is normally produced through a range of sizes up to about 75mm Both BOS and EAF steel slag have similar physical and chemical properties, typical properties are detailed in Austroads Guide Part 4E - Recycled Materials Steel slag...

Know More

Feasibility Study of Dephosphorization of Slag Generated ,

XRD and Scanning electron microscope SEM analysis were carried out for characterizing different property of BOF slag The slag was then crushed and heated at several rates and dwell time up to 1500 176 C Afterward it was cooled to 1400 176 C at the rate of 1 176 C/min with holding period of 240 min and then quenched with water...

Know More

Vol 2, Issue 3, March 2013 Steel Slag ingredient for ,

The chemical and physical properties of steel slag were examined and are stated in Table I and II 3 The specific gravity of SSA was found to be 258 , It was crushed down to 20 mm size for use as a coarse aggregate in concrete The sand used in concrete was local river sand and the natural coarse aggregate was 20 mm crushed granite 4...

Know More

Slag for Driveway

Dec 16, 2004 0183 32 Turns out there is not much difference in price between slag, crushed concrete and limestone There is a noticable difference in price between delivery methods 15/ton delivered with a 25 ton 3 axle but only 12 per ton for a double trailer road train that carries 50 tons a trip...

Know More

EFFECT OF USING STEEL SLAG AGGREGATE ON MECHANICAL ,

properties of concrete, the properties of the aggregates have a great importance Beshr et al , 2003 Maslehuddin et al 2002 have indicated that the durability of steel slag cement concrete is better than the same for crushed limestone aggregate Therefore, a thorough evaluation is necessary before using any...

Know More

NATIONAL SLAG ASSOCIATION

properties, and tasting of blast furnace slag for highway improvement 49 219 National Slag Association abrasion investigation 190 26 234 190 to 1 189 26 230 Bulk Density A widely used method of ascertaining the suitability of a slag for a given use is the determination of its bulk density, or weight per cubic foot, usually referred to as unit...

Know More

Gravel Driveway

May 30, 2003 0183 32 I heard sharp sand is now recommended under pavers as the slag sand used in the past is pourous and holds water In the winter it freezes and heav Anyway that s what Unilock told me There was a few pieces of steel but nothing major Got the material from Michigan Crushed Concrete and was pretty impressed with the quality of the material...

Know More

Densities of Common Materials

Densities of common products in both Imperial and SI-units Related Topics Material Properties - Material properties for gases, fluids and solids - densities, specific heats, viscosities and more Density - Density of different solid materials, liquids and gas Definitions and convertion calculators...

Know More

Duraberm Durable, Cost

Steel furnace slag is a co-product of the steel making process and Edw C Levy Co reclaims this as a cost-effective and durable aggregate for road building Duraberm, which is made from steel furnace slag, is a strong and sustainable material that holds up under heavy truck traffic, provides long service life, and helps control project cost...

Know More

crushed slag properties

This nonmetallic slag material can either be crushed and screened for aggregate use steel slag aggregates , or sintered and recycled as flux material in the iron and steel furnac Steel slag aggregates generally exhibit a propensity to expand This is because of the presence of free lime and magnesium oxides that have not reacted with the ,...

Know More

Properties of Unsaturated Polyester Mortars Using Crushed ,

crushed waste glass as a substitute for fine aggregates is explored The purpose of this investigation is to ascertain the properties of the UP mortars using crushed waste glass UP mortars using crushed waste glass are prepared with ground calcium carbonate, blast furnace slag and fly ash as filler, 2 the UP-fine aggregate ratios, crushed waste...

Know More

Comparison of properties of steel slag and crushed ,

Some of the important properties of the steel slag and crushed limestone aggregates are summarized in Table 4 The physical properties of steel slag aggregates are superior to those of crushed limestone aggregat The major difference between the steel slag and crushed ,...

Know More

Estimating the Physical Properties of Slags KC Mills ,

Estimating the Physical Properties of Slags , coarsely crushed with a hammer after cooling and stored in PE vessels in an evacuated desiccator until further pro- cessing , The slag property ....

Know More

Construction aggregate

Construction aggregate, or simply aggregate , is a broad category of coarse to medium grained particulate material used in construction, including sand, gravel, crushed stone, slag, recycled concrete and geosynthetic aggregat Aggregates are the most mined materials in the world...

Know More

Nonferrous Slags

Crushed fines, having high angularity, should be used rather than natural sand to lock-up the smooth, hard nickel slag aggregat ENGINEERING PROPERTIES Some of the engineering properties of nonferrous slag aggregates that are of particular interest when nonferrous slags are used in granular base applications include gradation, specific ....

Know More

Properties of Concrete used in Ferronickel Slag Aggregate

properties of concrete used ferronickel slag aggregate and durability of slag concrete Keywords Ferronickel slag, aggregate, concrete, mechanical property, durability INTRODUCTION Ferronickel slag is an industrial by- products that produced refining ferronickel from nickel or...

Know More

Crushed Stone Grades A Complete Guide

Crushed stone is a basic material used in various capaciti It is a widely used raw asset in the construction industry The extraction of hard rock that is turned into various crushed stone grades is a great economic indicator Crushed stone is and will continue to be a very integral part of things we build...

Know More

Tarmac Slag Aggregates

By-products of the steel and iron industries, slag aggregates have many valuable properties that can be used in construction, infrastructure and agriculture At Tarmac we have over 40 years experience of processing slag into premium and more sustainable construction materials...

Know More

Effect of crushed air

Jul 14, 2012 0183 32 Read Effect of crushed air-cooled blast furnace slag on mechanical properties of concrete, Journal of Wuhan University of Technology-Mater Sci Ed on DeepDyve, the largest online rental service for scholarly research with thousands of academic publications available at your fingertips...

Know More

Comparison of properties of steel slag and crushed ,

The durability performance of both steel slag and crushed limestone aggregate concretes was evaluated by assessing water permeability, pulse velocity, dimensional stability and reinforcement ....

Know More

The Use of Crushed Slag as Submerged Arc Welding Flux

The article discusses the differences of using virgin flux and crushed slag as submerged arc welding SAW flux in welding process It states that virgin flux has disequilibrium state when melted by a welding arc, although the specific elements contained in the slag may be similar...

Know More

Use of Crushed Gravel as a Driveway Material

Crushed gravel driveways are commonly composed of sand, silt, clay and larger aggregates pebbles and small stones Stone driveways, by contrast, are often more elegant The source of the confusion over terminology is that the small stone used in stone driveways is sometimes also referred to as gravel...

Know More

Aggregates for Concrete

Crushed stone is produced by crushing quarry rock, boul-ders, cobbles, or large-size gravel Crushed air-cooled blast-furnace slag is also used as fine or coarse aggregate The aggregates are usually washed and graded at the pit or plant Some variation in the type, quality, cleanli-ness, grading, moisture content, and other properties is expected...

Know More

Common Uses for Slag National Slag Association

Crushed and graded - for concrete aggregates, concrete sand, glass insulation wool, filter medium, and use under concrete slabs as a platform 2 , The blast furnace slag can impart many desirable properties to the masonry units such as lighter weight and increased fire resistance...

Know More